No spark!

Got an electrical gremlin? Ask the question here.
Post Reply
12callum
Engaged 4wd low
Engaged 4wd low
Posts: 142
Joined: Mon Feb 13, 2012 10:03 pm
Location: Marlborough

Re: No spark!

Post by 12callum » Tue Jul 02, 2013 6:51 pm

Didn't check that as my volt meter is in the old mans garage! I did swap the coil for the new one off the other truck but didn't make a difference? Or would that not work? Even rang the local garage but he said that they would of checked exactly what I had already checked! But I could drop it off with them! well there's no fun in that is there! Ill get the meter on it during the week and double check it!
Top
User avatar
Darrell
Suzuki, will you marry me?
Suzuki, will you marry me?
Posts: 2988
Joined: Wed Feb 23, 2011 7:54 pm
Location: south oxfordshire
Contact:
Contact Darrell

Re: No spark!

Post by Darrell » Tue Jul 02, 2013 8:01 pm

It certainly sounds like you have no power to the coil and dash. You could run a wire (fused at 15a) temporarily from the battery positive to the coil positive, leaving the existing wires attached to feed solenoid/dash.
This is just to see if it would run. If it does then obviously you have a break in the original wiring that will need finding.
2005-GV 1600se, "Hell" What do I know!
Top
User avatar
Tramp
Suzuki, will you marry me?
Suzuki, will you marry me?
Posts: 2829
Joined: Fri Jul 25, 2008 10:09 pm
Location: Rotherham - South Yorkshire

Re: No spark!

Post by Tramp » Tue Jul 02, 2013 8:44 pm

Darrell wrote:It certainly sounds like you have no power to the coil and dash. You could run a wire (fused at 15a) temporarily from the battery positive to the coil positive, leaving the existing wires attached to feed solenoid/dash.
This is just to see if it would run. If it does then obviously you have a break in the original wiring that will need finding.
And if it blows you know the 'proper' fuse has gone to, and that you have an earth fault on that leg of the circuit!
Top
12callum
Engaged 4wd low
Engaged 4wd low
Posts: 142
Joined: Mon Feb 13, 2012 10:03 pm
Location: Marlborough

Re: No spark!

Post by 12callum » Tue Jul 02, 2013 10:32 pm

Cracking idea darrell, I think I've got some old sub/amp wire lurking in the shed so ill give it a go! I must admit I was just stood staring at it earlier Completely bemused!
Top
User avatar
Darrell
Suzuki, will you marry me?
Suzuki, will you marry me?
Posts: 2988
Joined: Wed Feb 23, 2011 7:54 pm
Location: south oxfordshire
Contact:
Contact Darrell

Re: No spark!

Post by Darrell » Sat Jul 06, 2013 11:38 pm

Did you find what's wrong..
2005-GV 1600se, "Hell" What do I know!
Top
12callum
Engaged 4wd low
Engaged 4wd low
Posts: 142
Joined: Mon Feb 13, 2012 10:03 pm
Location: Marlborough

Re: No spark!

Post by 12callum » Sun Jul 07, 2013 1:01 am

ok so ive runn a wire from the battery + to the coil + and the lights on the dash worked but were on constantly, even with the ignition off, obviously! But still no spark! It's turning over ok and there's fuel getting through but it just doesn't want to fire! :S I'm away this weekend so will have to wait till next week but if anyone can help! My first thought is the dizzy? It's electronic but don't want to take it apart before I have a read up on them!
Top
User avatar
Darrell
Suzuki, will you marry me?
Suzuki, will you marry me?
Posts: 2988
Joined: Wed Feb 23, 2011 7:54 pm
Location: south oxfordshire
Contact:
Contact Darrell

Re: No spark!

Post by Darrell » Sun Jul 07, 2013 9:52 am

Here is a link to the "Ignition" section of the workshop manual http://www.4x4.in.th/manual_sj413/chapter8.pdf

Your need that multimeter though ;)
2005-GV 1600se, "Hell" What do I know!
Top
Post Reply

Return to “Electrical”