SJ noisy final drive

Starts at the flywheel, ends at the hubs, any problems along them lines, ask your questions here.
Post Reply
User avatar
djc
Can I have a tow
Can I have a tow
Posts: 282
Joined: Sat Jun 07, 2014 6:11 am
Location: Sevenoaks, Kent

SJ noisy final drive

Post by djc » Sat Mar 18, 2017 8:47 am

Hi all, sorry been away from here, busy but the 85 SJ going good, generally.
(This is a 2wd road condition)
Have a noise - at low speeds: take foot off accelerator but leave clutch engaged (so engine is braking a bit) - sounds rough, a bit graunchy. Drop the clutch and freewheel, all is calm, noise gone.
I have a guess there is excess rotational play somewhere in the drivetrain, and the noise is a sort of rotational resonance between engine and back wheels. I should check diff play and UV joints first I think.-?-
I'm tempted to start at the back and work forward - back axle/diff is 410. How much rotational play on the input shaft, anyone know the right amount or an acceptable tolerance please?
I'm pretty sure the gearbox and T-case are good.
Ideas and advice appreciated as always.
Straight n shiny '85 410 soft top.

Douglas

User avatar
Jordi
Bow down before me
Bow down before me
Posts: 7530
Joined: Sun Nov 29, 2009 2:35 pm
Location: Darlington, Co. Durham

Re: SJ noisy final drive

Post by Jordi » Sat Mar 18, 2017 9:01 am

Clutch release bearing is my guess. Given the noise goes when clutch is pressed.
1988 Samurai - Truck Cab & Tray Back - 1.6 8v & HIF44 - Snorkel - Stack Exhaust - PAS, YJs & 33s - Trussed, Gusseted & Pumpkin Capped Axles - 4.3 R&Ps - 4.16 T/Box - Rear Air Locker - Full Float Back Axle & Discs - RCV Front Shafts - X-Eng Handbrake - Custom Fuel Tank

User avatar
zook123
SCUK Addict
SCUK Addict
Posts: 948
Joined: Sun Apr 20, 2008 10:48 pm
Location: Shepton Mallet

Re: SJ noisy final drive

Post by zook123 » Sat Mar 18, 2017 5:20 pm

Jordi wrote:Clutch release bearing is my guess. Given the noise goes when clutch is pressed.

I'll second that, mine was the same until I stuck a new clutch in.
Image
2002 Jimny O2 Ragtop
Safari Snorkel, Freewheeling Hub Conversion
Diff Breathers, G/Box and T/Box Breathers, 2in Suspension Lift
HD Recovery Points and Winch Plate
Kuhmo KL71 MT / Goodyear Wrangler AT


Wessex 4X4 Reponse - WE411
wessex4x4response.org.uk

User avatar
andyrew
SCUK is my life
SCUK is my life
Posts: 1820
Joined: Fri Jul 31, 2009 12:39 am

Re: SJ noisy final drive

Post by andyrew » Sat Mar 18, 2017 10:05 pm

Possibly a uj? Does it do it when accelerating?

Would be a bit quick for the thrust bearing to fail unless its a faulty part.
Andys Rusty Suzuki Emporium

User avatar
andyrew
SCUK is my life
SCUK is my life
Posts: 1820
Joined: Fri Jul 31, 2009 12:39 am

Re: SJ noisy final drive

Post by andyrew » Sun Mar 19, 2017 12:59 am

Also, is it at any particular speed, rpm or in a certain gear?
Andys Rusty Suzuki Emporium

User avatar
djc
Can I have a tow
Can I have a tow
Posts: 282
Joined: Sat Jun 07, 2014 6:11 am
Location: Sevenoaks, Kent

Re: SJ noisy final drive

Post by djc » Sun Mar 19, 2017 4:34 pm

Hi Andy - it's low speeds, in traffic or dropping from say 30 to stop. We put a new clutch in only about 1k miles ago (well, you did really !).
Fine accelerating, it's only when engine is acting as a brake, then disconnect engine (drop clutch), all fine again.
Straight n shiny '85 410 soft top.

Douglas

Post Reply