Changed the fuel pump but theres something wrong

[Smalljeep]

sorry
all sorted now

[Henry]

Still not working

[Smalljeep]

http://www.youtube.com/watch?v=6uO0htE9R8w" onclick="window.open(this.href);return false;

Click Here for Youtube Video


its set as public now

[Henry]

Have you checked to see if your pulling in air.

To me sounds like the new pump diahpram is buggered. Stick the old one back on

[ROBBIE]

is all the pluming still where it should be on the carb?

[Smalljeep]

all the plumbing is untouched, i changed back to the old pump, and then did the video.

[ScottieJ]

Bit of a long shot but you haven't somehow broken a wire on or dissconnected the fuel stop solenoid during the swap? I had a similar issue and all it was was the earth wire snapped

IMAG0673.jpg (1.09 MiB) Viewed 6399 times

Mine has a green connection but some are brown. Follow the wires to wherever they go on the otherside of the connection, one wire should go to an ignition live and the other to an earth somewhere.

Also might be worth checking the fuel filter for blockages? Or even Stripping the carb to clean the jets?, its not that difficult, i'll try and find a write up, I used to jag some pics of my own somewhere

[Smalljeep]

the green plug on the thermostat ill have a check to see if its been knocked, but the engine did run smooth since the engine was put into the anus.

As for rebuilding the carb isnt that suzuki carb an absolute pig to work at, all wee small starheads that just run the heads off when you try and open them, but ill give it a go anyhow.

[Smalljeep]

hi
i noticed that a earth wire was loose, reconnected it and hey presto it ran nice.
But the problem is still about these 2 fuel pumps they are obviously both crap, its a waste of a good gasket swapping them over all the time, the one in at the moment is excreting a black fluid most likely oil. My mechanic had a look at them and said they are knackered.
Can i blank it off and put in an electric fuel pump, is the plumbing complicated most concerned about the return pipe as electric pumps seem only to have an in and an out pipe nothing for return, and do they work at the right speed?

[Smalljeep]

i had a look on ebay, this is a reasonably priced fuel pump, can i fit this to the suzuki, how many people have done this?